↓ Advertise on Defender2 ↓

Home > Puma (Tdci) > puma gearbox - thoughts
Post Reply  Down to end
Page 1 of 1
Print this entire topic · 
Caterham



Member Since: 06 Nov 2008
Location: Birmingham
Posts: 6300
England 2011 Defender 110 Puma 2.4 XS CSW Stornoway Grey
puma gearbox - thoughts
as mentioned elsewhere I should be replacing my gearbox in the not too distant......

question being should I retain the old box for a rebuild and potential refit in years to come or sell it?

If I sell any thoughts on where best to sell it and at what sort of cost. the box will have completed circa 50k miles as it was a replacement under warranty when my def was approx. 2 years old.

thoughts / suggestions much appreciated.
Post #552452 30th Jul 2016 7:42pm
View user's profile Send private message View poster's gallery Reply with quote
blackwolf



Member Since: 03 Nov 2009
Location: South West England
Posts: 17444
United Kingdom 2007 Defender 110 Puma 2.4 DCPU Stornoway Grey
Keep it to put back in when you find that either the "new" one is worse, or that the new one doesn't align with the transfer box as well as the old and your output adaptor shaft joint now only lasts 1500 miles between failures.
Post #552466 30th Jul 2016 8:52pm
View user's profile Send private message View poster's gallery Reply with quote
Caterham



Member Since: 06 Nov 2008
Location: Birmingham
Posts: 6300
England 2011 Defender 110 Puma 2.4 XS CSW Stornoway Grey
Erm... Shocked Confused

And some more Shocked

Rolling with laughter Thud

.....i'm prepared to take a chance Mr. Green


Perhaps I'll keep it just in case tho.
Post #552470 30th Jul 2016 8:59pm
View user's profile Send private message View poster's gallery Reply with quote
Pickles



Member Since: 26 May 2013
Location: Melbourne
Posts: 3785
Australia 2013 Defender 90 Puma 2.2 CSW Keswick Green
What's wrong with the "old" one, how "old" is it, & how many miles has it done?
Pickles.
Post #552473 30th Jul 2016 9:03pm
View user's profile Send private message View poster's gallery Reply with quote
Caterham



Member Since: 06 Nov 2008
Location: Birmingham
Posts: 6300
England 2011 Defender 110 Puma 2.4 XS CSW Stornoway Grey
G'day Pickles

Possibly nothing but through a process of elimination I'm determined to sort my rather annoying intermittent clatter.

It's my second box and has done approx 50k miles.

I suspect as a minimum either slave cylinder or restricter valve are pants and the box has to come out anyway so while at it I might as well change the box and check out the clutch and adapter shaft too Thumbs Up
Post #552477 30th Jul 2016 9:10pm
View user's profile Send private message View poster's gallery Reply with quote
Morepower



Member Since: 08 Jan 2013
Location: Fife, Scotland
Posts: 630
New Zealand 
If it changes gear, without any noises (grauging) between gears. Then I would suggest the gearbox is ok... Obviously check/change the oil whilst it's out.. The Clatter is more than likely to be the clutch.. removal of the gearbox should confirm this...
The TDCi gearboxes should be good for 250K plus if looked after.. It's just all the bit LR bolt on/in/around them that are usually suspect.. Clutch, Transfer box, Output shaft...ETC

Tim It doesn't matter how bad it is, It can always get worse...

2013 Bowler 110 (Sold)
2016 Bowler 90 Rally Spec (Sold)
Post #552550 31st Jul 2016 8:07am
View user's profile Send private message View poster's gallery Post Reply
Post Reply  Back to top
Page 1 of 1
All times are GMT

Jump to  
<  Previous Topic | Next Topic >
Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



Site Copyright © 2006-2024 Futuranet Ltd & Martin Lewis
DEFENDER2.NET RSS Feed - All Forums