DEFENDER2.NET - View topic - central locking motor

↓ Advertise on Defender2 ↓

Home · FAQ · New Posts · My Posts · PMs · Search · Members · Map · Calendar · Profile · Donate · Register · Log In

Home > Puma (Tdci) > central locking motor

Page 1 of 1

Print this entire topic ·

bear100

Member Since: 22 Mar 2010
Location: South Wales
Posts: 1913

2010 Defender 110 Puma 2.4 USW Santorini Black

central locking motor

It looks like my locking motor on the rear drivers side if cooked

are they serviceable?
only had a quick look on ebay and they are going for £120!!!

I've greased everything and nothing is seized

anyone else had issues?

2016 Range Rover Autobiography 4.4 TDV8
2010 110 XS Utility 2.4TDCI
2010 Range Rover Sport TDV8 (gone)
2007 Discovery HSE TDV6 (gone)
1993 110 csw 200 tdi (gone)
1994 90 HT 300 tdi (gone)
1994 discovery 300tdi (gone)
90 hybrid 3.5 v8 (gone)
Range rover bobtail 3.5 v8 (gone)

31st Jan 2015 1:28pm

munch90

Member Since: 26 Oct 2013
Location: guildford
Posts: 3558

have you checked the wiring between body and door in the rubber joining tube ?

31st Jan 2015 1:40pm

K9F

Member Since: 12 Nov 2009
Location: Bournemouth
Posts: 9610

2008 Defender 90 Puma 2.4 XS CSW Stornoway Grey

You could perhaps get a multimeter and with the door open and door card off check the supply when selecting it to lock. Are these 'handed.' If not and it's not too much mither swap the rear two over and see if the fault transfers perhaps?

Pink and Orange (two seperate single coloured cables) are your lock/unlock motor inputs.

As Munch stated the gaitored umbilical cables is a known vulnerable weakspot. A gentle tug of each cable where it exits the gaitor normally reveals the culprit. If you go through life with your head in the sand....all people will see is an ar5e!!

Treat every day as if it is your last....one day you will be right!!

31st Jan 2015 1:42pm

bear100

Member Since: 22 Mar 2010
Location: South Wales
Posts: 1913

i will have to give that a try, i couldn't read anything on my multimeter it moves to quick!!
i did however have continuity across the two cables to earth, when central locking activated the continuity paused for a second so i am pretty sure the cables are intact

31st Jan 2015 3:12pm

munch90

Member Since: 26 Oct 2013
Location: guildford
Posts: 3558

I would check them visually not just by meter

31st Jan 2015 3:57pm

pj2106

Member Since: 20 Dec 2012
Location: Huntingdon AKA The Shire
Posts: 1500

2008 Defender 110 Puma 2.4 USW Stornoway Grey

I have a good spare motor bit sold vehicle now so yours for 60 posted 2008 110 2.4 XS Utility (Hagrid)
2002 90 TD5 Hardtop (Sully) Sold
1998 300TDi D1 (Billy) Sold

31st Jan 2015 5:19pm

K9F

Member Since: 12 Nov 2009
Location: Bournemouth
Posts: 9610

Check the cables first.....

As mentioned the pink and orange cables there is an excellent photo of the common issue in the simultaneous thread running below.

http://www.defender2.net/forum/topic34609.html If you go through life with your head in the sand....all people will see is an ar5e!!

Treat every day as if it is your last....one day you will be right!!

31st Jan 2015 5:32pm

bear100

Member Since: 22 Mar 2010
Location: South Wales
Posts: 1913

Cheers lads, I will check the wires in the morning,

Pj if the wires are good I will gave that motor off you

31st Jan 2015 6:51pm

pj2106

Member Since: 20 Dec 2012
Location: Huntingdon AKA The Shire
Posts: 1500

That's the reason I have it brought a new motor and then found wires broke but couldn't be botheredt I take new motor out lol 2008 110 2.4 XS Utility (Hagrid)
2002 90 TD5 Hardtop (Sully) Sold
1998 300TDi D1 (Billy) Sold

31st Jan 2015 7:37pm

bear100

Member Since: 22 Mar 2010
Location: South Wales
Posts: 1913

Fair play guys you were spot on

There was a broken wire in the rubber conduit, the cable Land Rover have used is not the best for the job it was very brittle

Replaced the faulty section and harmony has been restored

Thanks lads

Sorry pj

lol 2016 Range Rover Autobiography 4.4 TDV8
2010 110 XS Utility 2.4TDCI
2010 Range Rover Sport TDV8 (gone)
2007 Discovery HSE TDV6 (gone)
1993 110 csw 200 tdi (gone)
1994 90 HT 300 tdi (gone)
1994 discovery 300tdi (gone)
90 hybrid 3.5 v8 (gone)
Range rover bobtail 3.5 v8 (gone)

1st Feb 2015 9:56am

K9F

Member Since: 12 Nov 2009
Location: Bournemouth
Posts: 9610

Good news and a satisfactory result. Well done.

If you go through life with your head in the sand....all people will see is an ar5e!!

Treat every day as if it is your last....one day you will be right!!

1st Feb 2015 9:58am

Page 1 of 1

All times are GMT

Jump to

< Previous Topic | Next Topic >

Posting Rules

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum