DEFENDER2.NET - View topic - Puma Gremlins Wreaking Havoc (again)

↓ Advertise on Defender2 ↓

Home · FAQ · New Posts · My Posts · PMs · Search · Members · Map · Calendar · Profile · Donate · Register · Log In

Home > Puma (Tdci) > Puma Gremlins Wreaking Havoc (again) - Injector earth-ground

Page 1 of 1

Print this entire topic ·

Smoeandco

Member Since: 22 Jun 2021
Location: Sydney
Posts: 9

Puma Gremlins Wreaking Havoc (again) - Injector earth-ground

Hi brain trust,

The old girl (07 2.4 90) has decided to stop dead in its tracks as of a week ago. Looks like rain is getting in all the usual places and the under dash fusebox looks a little moist (although nothing blown). Steps of chaos are as follows:

1. Traction control light came and stayed on for a week or so. Felt bitey and underpowered for the week or two following.
2. Car turns over but wouldn't start on a cold morning. P0200-11 (2

code pulled from the BAS tool. Injector circuit - General electrical failure - circuit short to ground. Have checked the earthing points I can find and they look fine, no signs of corrosion and under-seat box is dry as a bone.
3. Roadside assist hardclearted the fault as the BAS tool couldn't - turned over and all was working fine again until the next morning when the same thing popped up.

Thinking its a dash-out, hairdry all wiring and replace injector harness job + sikaflex heater-blower entries and windscreen bits. Next steps will be to find a noid light and test the injector voltage and probably replace the injectors.

Has anyone experienced anything similar? No other codes to be found. Have checked injector harness on the bulkhead side but all looks pretty clear. Hoping water hasn't gotten into the ECU (although I'd expect more codes if so).

Thanks in advance - couldn't have happened at a worse time.

18th May 2023 12:27am

ickle

Member Since: 22 Jul 2010
Location: South Vendee
Posts: 1776

2008 Defender 110 Puma 2.4 CSW Alpine White

As a first off I'd use a good quality jump leads and run one from the battery -ve to the gearbox and another battery -ve to a good clean point on the bulkhead and try that, if it works run some additional earths around and then fix some leaks.

HTH Keith

18th May 2023 8:45pm

Page 1 of 1

All times are GMT

Jump to

< Previous Topic | Next Topic >

Posting Rules

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum