↓ Advertise on Defender2 ↓

Home > Puma (Tdci) > Wiring a Warn XP
Post Reply  Down to end
Page 1 of 1
Print this entire topic · 
crinklycrag



Member Since: 29 Apr 2011
Location: Skipton
Posts: 19
United Kingdom 2011 Defender 90 Puma 2.4 HT Coniston Green
Wiring a Warn XP
Have fitted a second hand Warn XP to a new shadow winch bumper and looking for some basic advice re wiring up. Previous owner had solenoid / control box in engine compartment of an older 90. seems little room to do the same on a TDCI. I understand that a cut out switch is necessary and some say the winch will need to be separately fused. Have little experience of motor electrics so some good practical advice would be gratefully received. Rolling Eyes Crinklycrag
Post #85627 22nd Aug 2011 8:52pm
View user's profile Send private message View poster's gallery Reply with quote
markb110



Member Since: 22 May 2010
Location: Guildford
Posts: 2632
England 2002 Defender 90 Td5 HT Epsom Green
Hi CC

I am in Guildford if you want to come over and see the set up i have.

At the most basic the postive and negative wires from the winch can go straight to the battery, there is an earth on the bottom of the winch motor that should be earthed to the chassis.

A cut out switch within arms length is a must for safety reasons. This is positioned on the positive near to the battery but again so that you can reach it from where you are seated.

I have the solenoid under the bonnet with a feed to the front wing for the remote which in turn is split so that i also have controls on the front of the cubby box.

The only fuse that i have is for the split charge system not for the winch, this is rated at 150 amps.

My car is a TD5 not a puma. I am sure that someone has posted a picture of the solenoid under the bonnet near the back. My wich is a warn 9.5xp

Send me a pm if you want to come over

Mark
Post #85636 22nd Aug 2011 9:22pm
View user's profile Send private message View poster's gallery Reply with quote
crinklycrag



Member Since: 29 Apr 2011
Location: Skipton
Posts: 19
United Kingdom 2011 Defender 90 Puma 2.4 HT Coniston Green
Hi Mark,

Your offer is very much appreciated. I will send you a PM. Very Happy Crinklycrag
Post #85935 24th Aug 2011 8:22pm
View user's profile Send private message View poster's gallery Post Reply
Post Reply  Back to top
Page 1 of 1
All times are GMT

Jump to  
<  Previous Topic | Next Topic >
Posting Rules
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum



Site Copyright © 2006-2024 Futuranet Ltd & Martin Lewis
DEFENDER2.NET RSS Feed - All Forums