DEFENDER2.NET - View topic - Coolant Loss but how much?

↓ Advertise on Defender2 ↓

Home · FAQ · New Posts · My Posts · PMs · Search · Members · Map · Calendar · Profile · Donate · Register · Log In

Home > Tdi > Coolant Loss but how much?

Page 1 of 1

Print this entire topic ·

MattH268

Member Since: 01 Dec 2021
Location: Moray
Posts: 66

2013 Defender 110 Puma 2.2 HCPU Fuji White

Coolant Loss but how much?

Hi, this is probably going to be a really stupid question so I apologies, but I can't find an answer by searching anywhere. My 300tdi has been leaking a smidge of coolant from the header tank cap not a lot and I've been meaning to replace it. Yesterday after a drive I saw coolant dripping off the chassis leg and steering damper & guard. This time the rad cap was a bit loose, but the seal had been damaged. I have a Allisport Header Tank and Allisport full size radiator. The sight on the Header tank is about half and I don't know if it should be a bit more than this. When I had the rad cap off the level was about an inch and a half down, should this be full?

Simply my question is, on an Allisport sight gauge what should the level be? I can't find this anywhere and it's probably really stupid to ask and second should the rad be full?

I'm about to set off to collect the wife from the airport and hopefully it's ok. All I've done is tighten the caps and add an O-ring to the rad cap, but I don't have coolant and I don't know how much has been lost.

Many Thanks Matt 300tdi 90 CSW
2.2tdci 110 HCPU
1972 Series 3 88" Truck Cab

3rd Dec 2023 7:38pm

geobloke

Member Since: 06 Nov 2012
Location: Nottinghamshire
Posts: 4410

I would suspect 2/3rds to 3/4s full and get that cap sorted ASAP

The Iveco one with the hose bayonet is an excellent cap.

3rd Dec 2023 9:41pm

MattH268

Member Since: 01 Dec 2021
Location: Moray
Posts: 66

Thanks for the reply, I'd seen posts about the Iveco cap, but it seemed to be for TD5 & Puma not 300tdi & I didn't know if all of the header tanks used the same cap? I was going to order the NTC7161 stock cap that's been on the vehicle for a good while, but I'll see what I can find. 300tdi 90 CSW
2.2tdci 110 HCPU
1972 Series 3 88" Truck Cab

4th Dec 2023 7:12am

geobloke

Member Since: 06 Nov 2012
Location: Nottinghamshire
Posts: 4410

I could be wrong but I thought the caps were interchangeable between the 200/300/TD5/TDCI. Appear to be the same thread pattern anyway.

4th Dec 2023 7:17pm

MattH268

Member Since: 01 Dec 2021
Location: Moray
Posts: 66

All sorted, topped up with the same red/pink coolant, new rad & thermostat O-rings and a new stock cap. The expansion tank cap on my 2.2 is much smaller than the cap on the 300tdi so at least 2 different types.

Also just repaired the heater duct with a new seal and lined it up as it had about an inch gap hopefully it gets more airflow now!

M 300tdi 90 CSW
2.2tdci 110 HCPU
1972 Series 3 88" Truck Cab

26th Dec 2023 5:14pm

custom90

Member Since: 21 Jan 2010
Location: South West, England.
Posts: 20418

Take a look around the radiator, coolant hoses and connections whilst you are there, a minor leak under pressure can be a small leak only.
Also the water pump too, especially the edge nearest the floor for coolant traces usually dye can be dry or just a drip.

You can sometimes get just a very small leak that only loses a very small amount of coolant when hot, and under pressure, then dries up.
Typically just a little top up of coolant once or twice a year, I find is normal.
But more than that, more than 1L in a year or having to periodically add more every month or two, usually there is a minor leak.
And from there will usually get slowly worse over so many more months after that, mid winter is usually when it can occur due to temperature dropping and more excessive expansion and contraction just due to the normal changes in outdoor temperature.
A good coolant usually keeps things in good order, I replaced mine (the coolant) a couple of years ago but, it’s got a long life on modern coolant manufactures. $W33T $0U7H3RN $UG4R
🇬🇧🏴󠁧󠁢󠁥󠁮󠁧󠁿🏴󠁧󠁢󠁷󠁬󠁳󠁿🏴󠁧󠁢󠁳󠁣󠁴󠁿🇮🇪🇺🇸⛽️🛢️⚙️🧰💪

26th Dec 2023 9:23pm

MattH268

Member Since: 01 Dec 2021
Location: Moray
Posts: 66

Duly noted to check when driven again. My 300tdi hasn't been used in the last few weeks but I'd not really had the chance to fit the new expansion cap & seals which I knew were damaged and where all of the coolant had collected around. 300tdi 90 CSW
2.2tdci 110 HCPU
1972 Series 3 88" Truck Cab

27th Dec 2023 9:19am

Page 1 of 1

All times are GMT

Jump to

< Previous Topic | Next Topic >

Posting Rules

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum